Sunday, July 01, 2007

Using Templates for Machine Appliqué

There are a couple of beginner-friendly techniques for machine appliqué which use templates.

Posy Posy Posy

One approach uses freezer paper and a glue stick; for the other, you'll need some sort of heat-resistance template material (I used lightweight cardboard) and starch. The two blocks on the left were created using the freezer paper-glue stick approach; the one on the right was made using a heat-resistant template and starch.


For this method, you'll need freezer paper, a water soluble glue stick, a towel and some water.
  1. Trace the design onto the non-shiny side of a piece of freezer paper.

  2. Cut out the template (on the line) and iron it to the wrong side of the flower fabric.

    Create Freezer Paper Template Iron Freezer Paper to Fabric

  3. Cut out the fabric, leaving approximately 1/4 inch seam allowance.

    Trim the fabric

  4. Using a piece of scrap paper to work on, apply glue stick to the seam allowances. Fold them back and stick them to the freezer paper. You will need to clip the fabric wherever there are inside curves.

    Glue Seam Allowances Flower Applique

    Your appliqué is now ready to use.

    Flower Appliqué Ready to Use

  5. Using this technique, you do not need to make a template for the center of the Posy. The center fabric can be rough cut - it should be large enough to fit behind the flower element, extending beyond the edge at least 1/4 inch, but make your life easier and be generous. The center fabric should be prepared like the background, starched and pressed.

  6. Begin assembling the block by sewing the flower to the center fabric. You can hold it in place with pins or a little glue stick. After it's sewn, turn the appliqué piece over and trim the excess center fabric, leaving a 1/4 inch seam allowance.

    Flower with Center Fabric Trim Center

  7. Place the Posy appliqué on the center of your background square. Pin or glue-stick in place.

    Place and PIn on Background

  8. Stitch the Posy in place, then turn over the block and cut away the background fabric behind the flower.

    Stitched Posy Block Trim Back

  9. To remove the freezer paper, you must first loosen the glue. place the block on a towel and spray with water. (Again, my advice is to be generous and make your life easy - it's only water.) Use a q-tip, orange stick or similar tool to lift the seam allowances from the freezer paper, so you can remove it. Let the block dry and press or press it dry.

  10. Square up the block and trim to 8.5 inches. You're done.


    This block was sewn using clear mono-filament with a blind hem stitch.

For this method, you'll need liquid or spray starch and some sort of heat-resistant template material. It could be heat-resistant template plastic (made especially for this technique) or some lightweight cardboard, like I used in my sample block. You'll also need q-tips or a small brush.
  1. Create a template from your pattern.

  2. Trace the template on the BACK of your flower fabric

    Make Template
    Trace Template

  3. Cut out the flower fabric, leaving approximately 1/4 inch seam allowance. Clip any inside curves, up to, but not into the drawn line.

  4. Take template and fabric to the ironing board. Put the fabric right side down and place the template over it, lining it up on your drawn lines. Using a small brush or q-tip paint the starch on the seam allowance. If you are using spray atarch, you can spray some inside th lid then use the liquid with your brush. Fold the painted seam allowances up over the template and press in place.

    Trim Starch and Press Seam Allowances

  5. Allow the fabric and template to cool, then gently remove the template. I press the fabric (and it's nicely turned under edge) one more time to make it nice and flat.

    Remove template Flower Applique is Ready

  6. The assembly of the block is similar to that with freezer paper templates. The center fabric should be starched and pressed then pinned in place.

  7. Stitch the flower to the center

    Posy Center Center Placed Behind Flower

  8. Turn the Posy over and trim the center fabric, leaving a 1/4 inch seam allowance.

    Back of Flower with Center Fabric Center Trimmed

  9. Center the Posy on the background square and pin in place. Stitch.
  10. Turn the block over and cut away the background fabric from behind the flower.

    Place Appliqué on Background Trim Back of Block

  11. Press the block, square up the block and trim to 8.5 inches and you're done .


    This block was sewn with purple matching thread using straight stitch.


Jane Ann said...

Okay, totally creeped out here. I open your blog and there's a tutorial on exactly what I've been doing today--even the shape (minus the circle center). EXACTLY. I use the heat-resistant Templar and spray starch.

Nice tutorial and you're generous to post it.

Granny Fran said...

This is such a helpful tutorial. Thanks for putting it together, which must have taken a bit of time.

sophie said...

Sorry to creep you out, Jane Anne. Your comment made me smile because I've been a little worried that the fried eggshape was a little too goofy (it's the block we're making for the block lotto on the forum on this month). I put it together for the block lotto, I thought the doll quilt swappers and others might find it useful, too.

Jodie said...

Hi Sophie,
Thanks for the comment on my blog. This is my first doll quilt swap too. I'm glad that you like my log cabin design. I think that i've looked at it for too long now and I just can't wait to get it in the post and out of my sight.

Great tutorial! Really easy to understand and nice clear pictures. Well Done! It can be really hard to write a tutorial and this one is perfect!


KC Quilter said...

Very, very good tutorials on two applique-preparing techniques!!! I use the heat resistent template/starch method a lot and like not having to remove paper later!!! I love your blog, by the way.

Fiona said...

Thanks so much for these tutorials. I love the look of applique but apart from fused-on, machine satin stitched I have never seriously tried it - your instructions are so nice and clear I might just have to give hand-applique a go!

Related Posts Plugin for WordPress, Blogger...